欢迎访问《生物质化学工程》，
生物质化学工程

生物质化学工程 ›› 2013, Vol. 47 ›› Issue (6): 1-5.doi: 10.3969/j.issn.1673-5854.2013.06.001

• 研究报告 •    下一篇

无规则羧基丁腈橡胶改性环氧树脂的制备及性能研究

常侠, 聂小安, 王义刚, 陈洁, 李科   

  1. 中国林业科学研究院林产化学工业研究所; 生物质化学利用国家工程实验室; 国家林业局 林产化学工程重点开放性实验室; 江苏省生物质能源与材料重点实验室, 江苏 南京 210042
  • 收稿日期:2013-07-12 修回日期:1900-01-01 出版日期:2013-11-30 发布日期:2013-11-30

Preparation and Properties of Random Carboxylated Butadiene Nitrile Rubber Modified Epoxy Resins

CHANG Xia, NIE Xiao-an, WANG Yi-gang, CHEN Jie, LI Ke   

  1. Institute of Chemical Industry of Forest Products, CAF; National Engineering Lab. for Biomass Chemical Utilization; Key and Open Lab. of Forest Chemical Engineering, SFA, Key Lab. of Biomass Energy and Material, Jiangsu Province, Nanjing 210042, China
  • Received:2013-07-12 Revised:1900-01-01 Online:2013-11-30 Published:2013-11-30

PDF (PC)

906

摘要： 以无规则羧基丁腈橡胶（RCBN）为改性剂，对羧基丁腈橡胶改性环氧树脂的制备工艺及产品性能进行了研究。利用红外光谱及化学分析法等手段，探讨了催化剂用量、反应温度和反应时间对改性环氧树脂性能的影响；通过固化产物力学性能分析，对改性环氧树脂固化性能进行了评价。结果表明：质量配比为环氧树脂：RCBN：催化剂为100：15：0.3的反应体系中于120℃，反应150 min，获得了环氧值0.40、黏度（40 ℃）90~95 Pa·s、酸值小于0.4 mg/g的改性环氧树脂产品，改性环氧/改性胺411固化产物剪切强度为18.41 MPa，断裂伸长率为4.41%；无规则羧基丁腈橡胶对环氧树脂有显著的增韧效果。

关键词: 无规则羧基丁腈橡胶, 环氧树脂, 改性, 性能

Abstract: The preparation of epoxy resin modified by random carboxylated butadiene nitrile rubber and the properties of its cured products were studied in this paper. By infrared spectrum and chemical analysis, the effects of catalyst dosage, reaction temperature and reaction time on the properties of modified epoxy resin were discussed. Through the analysis of the mechanical properties of the cured products, the modified epoxy resin and its application were evaluated. The results showed that the modified product of epoxy value 0.40 and viscosity 90-95 Pa·s were obtained under conditions of mass proportion of epoxy resin:RCBN:catalyst 100:15:0.3, reaction temperature 120 ℃ and reaction time 3 h. The shear strength and elongation at break of the cured products of modified epoxy resin modified amine 411 were 18.41 MPa and 4.41%, respectively. The random carboxylated butadiene nitrile rubber had obvious toughening effect on epoxy resin.

Key words: random carboxylated butadiene nitrile rubbe(RCBN), epoxy resin(EP), modification, properties

中图分类号: 

版权所有 © 中国林业科学研究院林产化学工业研究所　苏ICP备08107184号-5