氯化锌活化法制备多孔炭陶复合吸附材料

doi:10.3969/j.issn.1673-5854.2016.06.005

生物质化学工程 ›› 2016, Vol. 50 ›› Issue (6): 32-36.doi: 10.3969/j.issn.1673-5854.2016.06.005

氯化锌活化法制备多孔炭陶复合吸附材料

林冠烽^1,2, 蔡政汉³, 吴开金², 陈学榕³, 常颖萃², 黄彪³

1. 福建农林大学金山学院, 福建福州 350002;
2. 福建省林业科学研究院, 福建福州 350012;
3. 福建农林大学材料工程学院, 福建福州 350002

收稿日期:2016-06-08 出版日期:2016-11-30 发布日期:2016-12-03
通讯作者: 黄彪(1966-),男,教授,博士生导师,主要从事林产化学与工业的研究;E-mail:fjhuangbiao@hotmail.com E-mail:fjhuangbiao@hotmail.com
作者简介:林冠烽(1983-),男,福建泉州人,讲师,博士,主要从事林产化学与工业的研究;E-mail:guanfeng002@sina.com
基金资助:
国家自然科学基金资助项目（31400510）；省属公益类科研院所基本科研专项（2014R1011-5）；福建省科技重大专项（2014NZ003）

Preparation of Porous Carbon/Pottery Adsorptive Composite by Zinc Chloride Activation

LIN Guan-feng^1,2, CAI Zheng-han³, WU Kai-jin², CHEN Xue-rong³, CHANG Ying-cui², HUANG Biao³

1. Jinshan College of Fujian Agriculture and Forestry Universtiy, Fuzhou 350002, China;
2. Fujian Academy of Forestry, Fuzhou 350012, China;
3. College of Material Engineering of Fujian Agriculture and Forestry University, Fuzhou 350002, China

Received:2016-06-08 Online:2016-11-30 Published:2016-12-03

摘要/Abstract

摘要： 以氯化锌浸渍的木屑为原料，黏土为粘结剂，制备炭陶复合吸附材料。讨论了炭化温度和保温时间对其吸附性能的影响，并对其孔隙结构进行了表征。结果表明，随温度和保温时间的增加，炭陶复合吸附材料的碘吸附值和亚甲基蓝吸附值呈先上升后下降的趋势；木屑受到活化作用形成活性炭而发生收缩，在活性炭和陶土之间形成空隙，有利于形成孔隙结构发达的炭陶复合吸附材料。在温度500℃、保温时间1 h的较佳工艺条件下，制得炭陶复合吸附材料的比表面积为809.5 m²/g，总孔容积为0.298 cm³/g，中孔容积为0.185 cm³/g，微孔容积为0.113 cm³/g，炭陶的含炭量为60.7%，碘吸附值为680.5 mg/g，亚甲基蓝吸附值为165.0 mg/g。

关键词: 炭陶复合材料, 多孔, 黏土, 微观结构

Abstract: Carbon/pottery adsorptive composite was prepared by using sawdust dipped with zinc chloride as raw material and clay as binder.The effects of temperature and holding time on the adsorption capability of carbon/pottery composite were studied,and the pore structure was characterized.The results showed that the iodine adsorption value and methylene blue adsorption value of carbon/pottery composite rose at first and went down later with the increase of temperature and holding time.The sawdust formed activated carbon by activation and shrank,so the voids between the activated carbon and pottery were produced.This favored the development of pore structure of carbon/pottery composite.Under the optimal conditions of temperature 500℃ and holding time 1 h,the specific surface area,total pore volume,mesopore volume,micropore volume,the carbon content,iodine adsorption value and methylene blue adsorption value were 809.5 m²/g, 0.298 cm³/g, 0.185 cm³/g, 0.113 cm³/g, 60.7%, 680.5 mg/g and 165.0 mg/g,respectively.

Key words: carbon/pottery composite, porous, clay, microstructure

中图分类号:

TQ35

林冠烽, 蔡政汉, 吴开金, 陈学榕, 常颖萃, 黄彪. 氯化锌活化法制备多孔炭陶复合吸附材料[J]. 生物质化学工程, 2016, 50(6): 32-36.

LIN Guan-feng, CAI Zheng-han, WU Kai-jin, CHEN Xue-rong, CHANG Ying-cui, HUANG Biao. Preparation of Porous Carbon/Pottery Adsorptive Composite by Zinc Chloride Activation[J]. bce, 2016, 50(6): 32-36.

参考文献

[1] 孙康,何跃,卢辛成,等. 椰壳活性炭对气态氯化汞吸附作用的对比研究[J]. 生物质化学工程,2015,49(4):1-6.
[2] 林冠烽. 磷酸法自成型木质颗粒活性炭的制备过程与机理研究[D]. 北京:中国林业科学研究院博士学位论文,2013:1-15.
[3] MOLINA-SABIO M,GONZALEZ J C,RODRIGUEZ-REINOSO F. Adsorption of NH₃ and H₂S on activated carbon and activated carbon-sepiolite pellets[J]. Carbon,2004,42(2):448-450.
[4] YATES M,BLANCO J,AVILA P,et al. Honeycomb monoliths of activated carbons for effluent gas purification[J]. Microporous and Mesoporous Materials,2000,37(1/2):201-208.
[5] YATES M,BLANCO J,MARTIN-LUENGO M A,et al. Vapour adsorption capacity of controlled porosity honeycomb monoliths[J]. Microporous and Mesoporous Materials,2003,65(2/3):219-231.
[6] CARVALHO A P,MESTRE A S,PIRES J,et al. Granular activated carbons from powdered samples using clays as binders for the adsorption of organic vapours[J]. Microporous and Mesoporous Materials,2006,93(1/2/3):226-231.
[7] 林云昊,许勇进,黄满琴,等. 活性炭陶瓷复合材料的苯吸附特性[J]. 材料热处理学报,2011,32(10):34-38.
[8] 杨勇,钱运华,蒋金龙,等. 凹凸棒土和活性炭复合载体的制备及其在烟气脱硫中的应用[J]. 非金属矿,2011,34(2):25-27.
[9] 林冠烽,黄彪,陈学榕,等. 物理法制备炭陶复合吸附材料及其表征[J]. 林业科学,2010,46(12):125-129.
[10] 林冠烽. 炭/陶复合多孔吸附材料的研究[D]. 福州:福建农林大学硕士学位论文,2007:37-73.
[11] HU Z H,SRINIVASAN M P,NI Y M. Novel activation process for preparing highly microporous and mesoporous activated carbons[J]. Carbon,2001,39(6):877-886.
[12] ARRIAGADA R,GARCIA R,MOLINA-SABIO M,et al. Effect of steam activation on the porosity and chemical nature of activated carbons from Eucalyptus globules and peach stones[J]. Microporous Materials,1997,8(3/4):123-130.

氯化锌活化法制备多孔炭陶复合吸附材料

Preparation of Porous Carbon/Pottery Adsorptive Composite by Zinc Chloride Activation

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 2

编辑推荐

Metrics

本文评价

关于本刊

投稿指南

在线期刊

相关单位

联系我们

[1]	王慧敏, 马艳丽, 方桂珍, 李淑君. 碱木质素接枝聚丙烯腈多孔材料的性能表征[J]. 生物质化学工程, 2015, 49(1): 13-19.
[2]	卢陈君;沈梅锋;李建法. 天然高分子基载体对农药控制释放作用的研究进展[J]. 生物质化学工程, 2011, 45(4): 51-55.