欢迎访问《生物质化学工程》,

生物质化学工程 ›› 2020, Vol. 54 ›› Issue (4): 23-29.doi: 10.3969/j.issn.1673-5854.2020.04.004

• 研究报告 • 上一篇    下一篇

汽爆秸秆对磷矿粉溶解作用及其溶解残渣对小麦生长的影响

刘菲菲1,2(),王岚1,李佐虎1,陈洪章1,*()   

  1. 1. 中国科学院 过程工程研究所 生物质炼制工程北京市重点实验室, 北京 100190
    2. 中国科学院大学, 北京 100049
  • 收稿日期:2019-09-02 出版日期:2020-07-30 发布日期:2020-08-06
  • 通讯作者: 陈洪章 E-mail:18322532172@163.com;hzchen@ipe.ac.cn
  • 作者简介:刘菲菲(1996—),女,安徽宿州人,硕士生,主要从事生物质炼制工程; E-mail:18322532172@163.com
  • 基金资助:
    国家重点研发计划资助项目(2019YFB1503800);中国科学院洁净能源先导科技专项资助(XDA21060300)

Dissolving Effect of Steam Exploded Corn Stalk on Phosphate Rock Powder and Influence of Its Residual on Wheat Growth

Feifei LIU1,2(),Lan WANG1,Zuohu LI1,Hongzhang CHEN1,*()   

  1. 1. Beijing Key Laboratory of Biomass Refining Engineering, Institute of Process Engineering, Chinese Academy of Sciences, Beijing 100190, China
    2. University of Chinese Academy of Sciences, Beijing 100049, China
  • Received:2019-09-02 Online:2020-07-30 Published:2020-08-06
  • Contact: Hongzhang CHEN E-mail:18322532172@163.com;hzchen@ipe.ac.cn

摘要:

为探究生物质对磷矿粉的溶解作用,以玉米秸秆为原料,利用蒸汽爆破(汽爆)技术释放有机酸,在高温水热条件下溶解磷矿粉并制备含磷腐殖酸。通过实验对汽爆秸秆溶解磷矿粉工艺进行了探究及优化,并利用傅里叶红外光谱(FT-IR)、扫描电子显微镜(SEM)和X射线荧光光谱(XRF)进行分析和表征。研究结果表明:15 g汽爆秸秆与1 g磷矿粉以及75 mL水在170℃、加入10% CaCl2的条件下,反应3 h的溶磷量为1.46 mg/g(以秸秆质量计,下同)。加入与磷矿粉相同质量的NaHSO4后可使体系pH值降低至2,pH值的降低是磷溶出的关键因素,溶磷量提高为13.10 mg/g。溶磷后的秸秆制备腐殖酸作为小麦盆栽肥料,用量0.2%时,小麦株高、根长、叶绿素含量和相对电导率均显著高于空白组。

关键词: 玉米秸秆, 蒸汽爆破, 磷矿粉, 溶解, 腐殖酸

Abstract:

In order to explore the dissolving effect of biomass on phosphate rock powder, steam explosion was used to release organic acid from corn stalk(CS) to dissolve phosphate rock powder(PRP) under high temperature and hydrothermal conditions, at the same time, phosphorus-containing humic acid was prepared. The process of dissolving phosphate rock powder by steam exploded corn stalk(SECS) was explored and the optimal conditions were determined. The structures and properties were investigated by Fourier transform infrared spectroscopy(FT-IR), scanning electron microscopy(SEM) and X-ray fluorescence spectroscopy(XRF). The results showed that under the conditions of temperature 170℃, 15 g steam exploded corn stalk, 1 g phosphate rock powder, 75 mL water, adding 10% calcium chloride, reaction for 3 h, the amount of dissolved phosphorus was 1.46 mg/g(based on the mass of stalk). The addition of sodium bisulfate could lower the pH value of the system to below 2, and the amount of dissolved phosphorus could reach 13.26 mg/g. Under high temperature and hydrothermal conditions, partial humification of stalks could be directly used as fertilizer. After adding 0.2% humic acid, the plant height, root length, chlorophyll content and relative conductivity of wheat were significantly higher than those of the control group.

Key words: corn stalk, steam explosion, phosphate rock power, dissolution, humic acid

中图分类号: