过硫酸钠热激活法深度氧化竹材制浆废水生化出水的研究

doi:10.3969/j.issn.1673-5854.2014.05.001

生物质化学工程 ›› 2014, Vol. 48 ›› Issue (5): 1-6.doi: 10.3969/j.issn.1673-5854.2014.05.001

• 研究报告 • 下一篇

过硫酸钠热激活法深度氧化竹材制浆废水生化出水的研究

李四辉, 施英乔, 丁来保, 崔宏辉, 盘爱享, 房桂干

中国林业科学研究院林产化学工业研究所; 生物质化学利用国家工程实验室; 国家林业局林产化学工程重点开放性实验室; 江苏省生物质能源与材料重点实验室, 江苏南京 210042

收稿日期:2014-04-15 出版日期:2014-09-30 发布日期:2014-09-30
通讯作者: 施英乔（1957-），男，研究员，硕士生导师，主要从事制浆废水的研究和工程应用；E-mail：1276470735@qq.com。 E-mail:1276470735@qq.com
作者简介:李四辉（1988-），男，山东费县人，硕士生，研究方向为制浆造纸废水深度处理
基金资助:
“十二五”国家科技支撑计划资助（2012BAD23B0202）

Advanced Oxidation of the Biochemical Effluent of Bamboo Pulping Wastewater Based on Sodium Persulfate Activated by Heat

LI Si-hui, SHI Ying-qiao, DING Lai-bao, CUI Hong-hui, PAN Ai-xiang, FANG Gui-gan

Institute of Chemical Industry of Forestry Products, CAF; National Engineering Lab.for Biomass Chemical Utilization; Key and open Laboratory on Forest Chemical Engineering, SFA; Jiangsu Province Key Laboratory of Biomass Energy and Material, Nanjing 210042, China

Received:2014-04-15 Online:2014-09-30 Published:2014-09-30

摘要/Abstract

摘要： 研究过硫酸钠热激活法深度氧化竹材化学机械法制浆废水生化出水。结果表明，在温度为50℃，Na₂S₂O₈用量为1.5 kg/t时，化学需氧量（COD）达到最低值65 mg/L，COD去除率为54.86%，此时水质满足80 mg/L的国家排放标准。pH值对废水COD的影响体现在既可以在强酸性时产生木质素酸析效应，又可以在强碱性条件下影响过热激活过硫酸盐体系的自由基类型。自由基的反应性强、寿命短，反应可以在20 min内有效完成，延长反应时间，COD几乎不变。

关键词: 竹材, 过硫酸钠, 深度氧化, 制浆废水, 生化出水

Abstract: Activated sodium persulfate used as the AOTs to degrade the biochemical effluent of bamboo wastewater in chemical machanical pulp craft was investigated.The results indicated that when the dosage was 1.5 kg/t at 50℃,COD reached the lowest,65 mg/L,and the removal efficiency was 54.86%.Thus the effluent met the national emission standard,80 mg/L.The pH value could not only perform the lignin-precipitation-effect in strong acidity,but also affect the species of free radical in powerful alkaline in the heat activated persulfate system.The oxidation of pollutants could finish in 20 min because the free radicals had strong reactivity and short life.No change had occurred on the COD nearly with the reaction time prolonging.

Key words: bamboo, sodium persulfate, advanced oxidation, pulp wastewater, biochemical effluent

中图分类号:

TQ35
X703.1

李四辉, 施英乔, 丁来保, 崔宏辉, 盘爱享, 房桂干. 过硫酸钠热激活法深度氧化竹材制浆废水生化出水的研究[J]. 生物质化学工程, 2014, 48(5): 1-6.

LI Si-hui, SHI Ying-qiao, DING Lai-bao, CUI Hong-hui, PAN Ai-xiang, FANG Gui-gan. Advanced Oxidation of the Biochemical Effluent of Bamboo Pulping Wastewater Based on Sodium Persulfate Activated by Heat[J]. bce, 2014, 48(5): 1-6.

参考文献

[1] 陈晓旸.基于硫酸自由基的高级氧化技术降解水中典型有机污染物研究.大连:大连理工大学博士学位论文,2007.
[2] 关英红,马军,方晶云.UV/PMS体系中BrO₃^-的生成和控制[J].黑龙江大学自然科学学报,2012,29(4):526-529.
[3] PEYTON G R.The free-radical chemistry of persulfate-based total organic carbon analyzers[J].Marine Chemistry,1993,41(1):91-103.
[4] ANIPSITAKIS G P,DIONYSIOU D D.Degradation of organic contaminants in water with sulfate radicals generated by the conjunction of peroxymonosulfate with cobalt[J].Environmental Science & Technology,2003,37(20):4790-4797.
[5] BLOCK P A,Brown R A,Robinson D.Novel activation technologies for sodium persulfate in situ chemical oxidation.Proceedings of the Fourth International Conference on the Remediation of Chlorinated and Recalcitrant Compounds.2004:24-27
[6] 杨照荣,崔长征,李炳智,等.热激活过硫酸盐降解卡马西平和奥卡西平复合污染的研究[J].环境科学学报,2013,33(1):98-104.
[7] LIANG C J,BRUELL C J,MARLEY M C,et al.Persulfate oxidation for in situ remediation of TCE(Ⅰ).Activated by ferrous ion with and without a persulfate-thiosulfate redox couple[J].Chemosphere,2004,55(9):1213-1223.
[8] 赵进英,张耀斌,全燮,等.加热和亚铁离子活化过硫酸钠氧化降解4-CP的研究[J].环境科学,2010,31(5):1233-1238.
[9] 张乃东,朱正江,栾万利.日光/Fe²⁺/S₂O₈^2-体系中酸性刚果红的降解机理[J].化学学报,2011,69(19):2307-2312.
[10] KILLIAN P F.Peroxydisulfate oxidation of PCBs,chlorobenzenes and MGP waste[D].USA:University of Massachusetts Lowell,2004.
[11] LIANG C,BRUELL C J,MARLEY M C,et al.Persulfate oxidation for in situ remediation of TCE(Ⅱ).Activated by chelated ferrous ion [J].Chemosphere,2004,55(9):1225-1233.
[12] YANG S,WANG P,YANG X,et al.A novel advanced oxidation process to degrade organic pollutants in wastewater:Microwave-activated persulfate oxidation[J].Journal of Environmental Science,2009,21(9):1175-1180.
[13] PRICE J,CLIFTON A A,KEEN F.Ultrasonically enhanced persulfate oxidation of polyethylene surfaces[J].Polymer,1996,37(26):5825-5879.
[14] LAU T K,CHU W,Graham N J D.The aqueous degradation of butylated hydroxyanisole by UV/S₂O₈^2-:Study of reaction mechanisms via dimerization and mineralization[J].Environmental Science & Technology,2007,41(2):613-619.
[15] 沈建,唐大为,李心亮.注册环保工程师专业考试复习教材[M].3版.北京:中国环境科学出版社,2011:190-192.
[16] 詹怀宇,刘秋娟,陈嘉川,等.制浆原理与工程[M].3版.北京:中国轻工业出版社,2011:162-175.
[17] 林亲铁,刘国光,刘千钧.微波强化氧化处理难降解有机废水研究进展[J].工业水处理,2012,32(2):1-3.

过硫酸钠热激活法深度氧化竹材制浆废水生化出水的研究

Advanced Oxidation of the Biochemical Effluent of Bamboo Pulping Wastewater Based on Sodium Persulfate Activated by Heat

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 6

编辑推荐

Metrics

本文评价

关于本刊

投稿指南

在线期刊

相关单位

联系我们

[1]	王盟盟,刘乐群,刘震涛,赵莹. 竹材液化墙体泡沫材料的阻燃改性[J]. 生物质化学工程, 2020, 54(5): 25-32.
[2]	张华兰,房桂干,沈葵忠,邓拥军,李晓亮,韩善明. 慈竹薄壁组织的部分去除对化机浆制浆、漂白性能的影响[J]. 生物质化学工程, 2019, 53(4): 31-36.
[3]	张华兰, 房桂干, 施英乔, 沈葵忠, 冉淼, 韩善明, 丁来保, 盘爱享. 麦草两段预浸渍化机浆废水的污染物特征和发生量[J]. 生物质化学工程, 2016, 50(5): 39-44.
[4]	孙恩惠;孙丰文. 竹长条加工剩余物制备重组竹材的应用技术研究[J]. 生物质化学工程, 2012, 46(4): 11-16.
[5]	罗晔;费斌;郭嘉;鲍秀婷;HESLOP M J. 竹材炭化过程的热重分析及动力学研究[J]. 生物质化学工程, 2009, 43(6): 7-10.
[6]	傅深渊;栾复友;程书娜;赵广杰. 竹材液化物酚醛树脂胶固化及固化动力学研究[J]. 生物质化学工程, 2009, 43(4): 33-37.